compressive strength of concrete made with quarry dust

image

Vol. 6, Issue 3, March 2017 Comparing the Compressive ...

ABSTRACT: This study investigates the compressive strength (CS) of concrete made with river sand gotten from Osogbo, Osun State, replaced at 0- at intervals of 10% with quarry dust gotten from Wasimi, Osun State, Nigeria.

Contact Supplier

image

Improved Concrete Properties Using Quarry Dust as ...

Quarry dust has been proposed as an alternative to river sand that gives additional benefit to concrete. Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand. The Compressive strength of quarry dust concrete continues to increase with age for all the percentage of quarry dust contents.

Contact Supplier

image

Compressive Strength Of M25 Concrete By Using Quarry Dust

The use of quarry dust in concrete has shown to improve strength properties and increase the workability of concrete Kapgate and Satone and Shakir et al., investigated the fly ash brick and the incorporation of 50 % quarry dust by weight has significantly improved the compressive strength.

Contact Supplier

image

Compressive Strength by Incorporating Quarry Dust in Self ...

The study has conducted to determine the workability and compressive strength of the self –compacting concrete. The sand has replaced with quarry dust with the proportion of 10, 20, 30 and 40% and super plasticizer was added 0.9%.

Contact Supplier

image

EFFECT OF CHARACTERIZATION PROPERTIES ON COMPRESSIVE ...

compressive strength for 7, 14, 28, 90 days .The addition of fine quarry dust with ldpe as waste plastic in concrete resulted in improved matrix densification compared to conventional concrete.

Contact Supplier

image

Study on Strength Parameter of Conventional Concrete with ...

To study the strength behaviour of concrete made with different fly ash replacement levels (40% and 50%) and quarry dust replacement levels (10% and 20%). ... fly ash and 10% and 20% replacement of quarry dust for compressive strength (Figure 9) and Tensile Strength (Figure 10) is shown below. a) Compression Test

Contact Supplier

image

Concrete with Ceramic Waste and Quarry Dust Aggregates ...

For this research focus on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The source of ceramic waste and quarry dust from the industrial in Malaysia. Nowadays, in ceramics industries

Contact Supplier

image

application of quarry dust in concrete construction - Flat

It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete. KEYWORDS River sand Substitute- Quarry Rock Dust-Concrete mixes- Compressive Strength- Flexural Strength-gain in strength and shrinkage.

Contact Supplier

image

Can we make concrete using quarry dust as a replacement ...

It is not possible to make concrete out of quarry dust, since quarry dust is a waste product that is produced during M Sand / stone crushing process. To make concrete, it is necessary to make use of sand or M Sand (An alternative for river sand).

Contact Supplier

image

AN INVESTIGATION ON EFFECT OF QUARRY DUST AS SAND ...

strength of foam concrete by using quarry as partial sand replacement material. This report presents the feasibility of the usage of quarry dust as 10 %, 20 % and 30 % substitutes for sand in foam concrete.

Contact Supplier

image

International Conference on Recent Trends in Civil ...

Experimental Investigation of Concrete Made With Quarry Dust and Partially added of Cement by Lime Sludge Pradeep.V.R[1] Civil Department. PSR Engineering College, Sivakasi ... concrete. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. This result gives a clear

Contact Supplier

image

Mathematical Relationships between the Compressive ...

Keywords: Sand-quarry dust block, Compressive strength, Water absorption, Flexural strength, Split tensile Strength, Regression analyses, I. Introduction In most concrete tests, major emphasis is placed on the determination of the 28 day compressive strength. Often, not much is done to determine the values of the other parameters; the general ...

Contact Supplier

image

COMPARING THE COMPRESSIVE STRENGTHS OF CONCRETE MADE WITH ...

as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conventional concrete made with river sand. Key word : Quarry dust, river sand, compressive strength, water cement ratio, workability.

Contact Supplier

image

Use of Quarry Fine as Partial Replacement of Concrete as a ...

concrete made of Quarry Rock Dust for three different ... The compressive strength of concrete was determined using 150mm concrete cubes. The concrete was made by replacing 10, 15, 20% of the coarse aggregate by recycling aggregate and Coconut shells. Also concrete cubes

Contact Supplier

image

Quarry Dust as a Partial Replacement of Coarse Aggregates ...

Keywords: concrete, quarry dust, compressive strength, coarse aggregates, partial replacement I. Introduction Concrete is one of the most used building materials globally.

Contact Supplier

image

An Experimental study on compressive strength of Quarry ...

The compressive strength results of quarry dust concrete (cubes) were obtained where M20 grade of concrete with 10 percent increment up to 100 percent replacement of quarry dust is concentrated and the results are presented. The study aimed to observe the compressive strength properties of quarry dust by varying full percentage

Contact Supplier

image

(PDF) Stone Dust in Concrete: Effect on Compressive Strength

In the present investigation, an experimental program was carried out to study the workability and compressive strength of concrete made using stone dust as partial replacement of fine aggregate ...

Contact Supplier

image

compressive strength of concrete made with quarry dust

(d) The compressive strength results of quarry dust concrete (cubes) were obtained in the fourth series, where M20, M30, and M40 grades of concrete with 20, 30, and 40 percent replacement of quarry dust with water-cement ration of 0.45 are concentrated and the results are presented.

Contact Supplier

image

QUARRY DUST FINE POWDER AS SUBSTITUTE FOR …

Quarry Dust Fine Powder as Substitute for Ordinary Portland Cement in Concrete Mix 193 Journal of Engineering Science and Technology April 2014, Vol. 9(2) enhances compressive strength at hardened state [3].

Contact Supplier

image

Compressive Strength of Fly Ash Brick with Addition of ...

made to find the optimum mix percentage of to obtain maximum compressive strength of flyash brick admixed with lime, gypsum and quarry dust at various proportions. A. Sumathi et al /Int.J. ChemTech Res.2014-15, 07(01),pp 28-36.

Contact Supplier

image

Strength and Workability Properties of Concrete Replaced ...

the strength and stability of concrete containing quarry dust and GGBS as partial replacement of sand proposed as an alternative to sand that gives additional and cement at various percentages .

Contact Supplier

image

Effect of quarry rock dust on the flexural strength of ...

The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarry-sand concrete based on its compressive strength.

Contact Supplier

image

Compressive Strength and Water Absorption Characteristics ...

The use of quarry dust in concrete has shown to improve strength properties and increase the workability of concrete Kapgate and Satone and Shakir et al., investigated the fly ash brick and the incorporation of 50 % quarry dust by weight has significantly improved the compressive strength.

Contact Supplier

image

Compressive Strength and Costs of Sandcrete Blocks and ...

b. Compressive Strength Test – this guides to determine the compressive strength of both the sandcrete and quarry dust blocks respectively. The results obtained from these tests together with the conceptual theory formed the basis upon which conclusion and recommendations were made. In the research work, efforts were made to identify that ...

Contact Supplier

image

EXPERIMENTAL STUDY ON STRENGTH CHARACTERISTICS OF CONCRETE ...

The compressive strength of concrete with quarry dust and 25%, 30%, 35%, 40%, 45% and 50% flyash aggregate were tested is shown in the below graph. Test results of concrete cube specimens for M20 grade:

Contact Supplier

image

Compressive Strength and Costs of Sandcrete Blocks and ...

strength of both the sandcrete and quarry dust blocks respectively. The results obtained from these tests together with the conceptual theory formed the basis upon which conclusion and recommendations were made.

Contact Supplier

image

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

helps in developing high performance and high strength in concrete. Quarry dust is a residue tailing or other non-voluble material after extraction and processing of rocks to form fine particle ... The compressive strength of concrete was determined at 7, 14 &28days of curing. Tests were carried out on 150x150x150mm size cubes. A 2000 kN ...

Contact Supplier

image

cast iron soil pipe crushing strength quarry rock dust ...

effect of quarry dust on compressive strength concretequarry dust, and cement.Effects of crushed stone dust on some prop. Use Of Rock Dust And Quarry Waste In Concrete - Crusher USA 2014615-About use of rock dust and quarry waste in concrete-related information:concrete is a composite material consisting of a binder, which is ty.

Contact Supplier

image

Partial Replacement of Sand by Quarry Dust in Concrete

Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre ... the Compressive strength of concrete will also increase ... Th e utilization of Quarry dust as a partial replacement of sand in concrete can reduce the cost of construction.

Contact Supplier

image

Compressive Strength and Water Absorption Characteristics ...

The use of quarry dust in concrete has shown to improve strength properties and increase the workability of concrete Kapgate and Satone and Shakir et al., investigated the fly ash brick and the incorporation of 50 % quarry dust by weight has significantly improved the compressive strength.

Contact Supplier